24V-523 Open recall Jul 9, 2024
Prevost Car (US) Inc.
EQUIPMENT ADAPTIVE/MOBILITY:WHEELCHAIR LIFT/RAMP
Prevost Car (US) Inc. (Prevost) is recalling certain 2005-2024 X3-45, 2017-2019 and 2021-2023 X3-45 Commuter, 2006-2007, 2014, and 2018 H3-41, 2005-2020 and 2022-2024 H3-45, and 2019 H3-45 VIP buses equipped with a wheelchair lift. The wheelchair platform bridging device may be too steep, which can cause the wheelchair to become unstable. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard numbers 403, "Platform Lift Devices" and 404, "Platform Lift Installations."
Risk: An unstable wheelchair increases the risk of injury to lift occupants.
Remedy: Prevost will replace the wheelchair lift bridging device, free of charge. Owner letters were mailed April 25, 2025. Owners may contact Prevost customer service at 1-866-870-2046. Prevost's number for this recall is SR24-26. The repair is free at any franchised dealer of your brand.
Read the full explainer → 18V-928 Open recall Dec 21, 2018
Prevost Cars, Inc.
STEERING:LINKAGES:DRAG:LINK:CONNECTION
Prevost Cars, Inc (Prevost) is recalling certain 2000 XL-45 buses, 2000-2006 XL2-45 buses and 2007-2014 X3-45 buses. The draglink tube turnbuckle may fracture causing a loss of steering.
Risk: A complete loss of steering would increase the risk of a crash.
Remedy: Prevost has notified owners, and dealers will replace the draglink, free of charge. Prevost issued an interim notification to owners on February 13, 2019. The recall began June 3, 2019. Owners may contact Prevost customer service at 1-866-870-2046. Prevost's number for this recall is SR19-04. The repair is free at any franchised dealer of your brand.
Read the full explainer → 17V-618 Open recall Oct 4, 2017
Prevost Cars, Inc.
FUEL SYSTEM, DIESEL:STORAGE:TANK ASSEMBLY
Prevost Cars, Inc. (Prevost) is recalling certain 2008-2018 H3-41, H3-45, H3-45 VIP, X3-45, X3-45 VIP, X3-45 VIP Entertainer, and XL2 motor coaches. The fuel tank cradle supports may have gaps at the points where the cradle connects to the coach frame, which can allow the attachment bolts to loosen and fail causing the fuel tank to fall from the vehicle.
Risk: If the fuel tank separates from the vehicle, it could be a road hazard and the vehicle would stall. Either scenario increases the risk of a crash.
Remedy: Prevost will notify owners, and dealers will correct the fuel tank cradle mounting, free of charge. The recall began on December 4, 2017. Owners may contact Prevost customer service at 1-866-870-2046. Prevost's number for this recall is SR17-28. The repair is free at any franchised dealer of your brand.
Read the full explainer → 15V-349 Open recall Jun 5, 2015
Prevost Cars, Inc.
ELECTRICAL SYSTEM:12V/24V/48V BATTERY:CABLES
Prevost Cars, Inc. (Prevost) is recalling certain model year 2006-2010 X3-45 coaches manufactured January 11, 2006, to April 12, 2010. The affected vehicles have booster stud connections that may rust. As they rust, the stud may weaken and break, allowing the power cable to ground against the vehicle frame.
Risk: If the power cable electrically shorts against the frame, there would be an increased risk of a fire.
Remedy: Prevost will notify owners, and dealers will install a protective box over the connection to prevent the power cable from contacting the frame if it comes loose. Any cable that is corroded will be replaced, free of charge. The recall began on July 24, 2015. Owners may contact Prevost customer service at 1-800-463-7738. Prevost's number for this recall is SR15-27. The repair is free at any franchised dealer of your brand.
Read the full explainer → 15V-122 Open recall Mar 2, 2015
Prevost Cars, Inc.
FUEL SYSTEM, DIESEL
Prevost Cars, Inc. (Prevost) is recalling certain model year 2007-2012 XLII, X3-45, H3-41, H3-45, and H3-45 VIP vehicles manufactured July 5, 2007, to May 11, 2012. The affected vehicles may be missing a fuel line locating clip, allowing the fuel line to rub against the braided coolant hose.
Risk: The fuel line rubbing may result in abrasion and a fuel leak, increasing the risk of a fire.
Remedy: Prevost will notify owners, and dealers will inspect the fuel line for abrasion, replacing it as necessary, and will properly secure the fuel line and coolant line, free of charge. The recall began on March 26, 2015. Owners may contact Prevost customer service at 1-418-883-3391. Prevost's number for this recall is SR15-04. The repair is free at any franchised dealer of your brand.
Read the full explainer → 14V-073 Open recall Feb 24, 2014
Prevost Cars, Inc.
ELECTRICAL SYSTEM
Prevost Cars Inc. (Prevost) is recalling certain model year 2008-2010 X3-45 Coaches equipped with Sure Power-brand DC to DC converters containing a particular epoxy sealing, aka 'potting', compound. The specific potting compound used in the subject products for insulation was found to be capable of conducting electricity after being exposed to heat.
Risk: Once electrically conductive, the material is capable of melting and burning, increasing the risk of a fire.
Remedy: Prevost will notify owners, and dealers will replace the converters, free of charge. The recall began on April 15, 2014. Owners may contact Prevost at 1-418-883-2888. Prevost's number for this recall is SR14-12. The repair is free at any franchised dealer of your brand.
Read the full explainer → 13V-534 Open recall Oct 29, 2013
Prevost Cars, Inc.
ELECTRICAL SYSTEM:12V/24V/48V BATTERY:CABLES
Prevost is recalling certain model year 2008-2009 X3-45 and X3-45 Entertainer coach buses manufactured November 2, 2006, through November 27, 2008. In the affected buses there are two battery cables. One of cables may have been inadvertently installed in a p-clamp. As a result, the cable that is not run through the p-clamp may rub against the p-clamp causing a short circuit.
Risk: A short may result in a vehicle fire.
Remedy: Prevost will notify owners, and dealers will remove the p-clamp, inspect, and replace the affected battery cable as necessary, free of charge. The recall began on December 16, 2013. Owners may contact Prevost at 1-418-883-2888. Prevost's recall number is SR13-73. The repair is free at any franchised dealer of your brand.
Read the full explainer → 13V-039 Open recall Feb 7, 2013
Prevost Cars, Inc.
VEHICLE SPEED CONTROL:ACCELERATOR PEDAL
Prevost is recalling certain model year 2008-2013 X3-45, H3-41 and H3-45 coaches, model year 2011-2013 H3-45 VIP coaches, model year 2012-2013 X3-45 VIP coaches, and model year 2009-2013 XLII-45 Entertainer coaches manufactured from May 16, 2007, through March 14, 2013 and equipped with Volvo engines. Certain conditions may cause the affected coaches to go into a software mode that would result in the throttle signal being fixed at 1700rpms regardless of throttle pedal input from the driver.
Risk: Uncontrollable throttle position may lead to a loss of vehicle control, increasing the risk of a crash.
Remedy: Prevost will notify owners and dealers will remedy will the affected coaches, free of charge. The recall began on May 2, 2013. Owners may contact Prevost at 1-418-831-2046. The repair is free at any franchised dealer of your brand.
Read the full explainer → 12V-315 Open recall Jul 6, 2012
PREVOST CARS, INC.
ELECTRICAL SYSTEM:12V/24V/48V BATTERY:CABLES
PREVOST IS RECALLING CERTAIN MODEL YEAR 2007-2009 X3-45 COACHES EQUIPPED WITH VOLVO D13 ENGINES. THE JUMP-START POSITIVE TERMINAL BLOCK CABLE MAY BE MISSING A PROTECTIVE SLEEVE, WHICH MAY ALLOW A SHORT-CIRCUIT IF IT CONTACTS OTHER VEHICLE STRUCTURES.
Risk: IF A SHORT-CIRCUIT OCCURS, THERE IS AN INCREASED RISK OF FIRE.
Remedy: PREVOST WILL NOTIFY OWNERS, AND DEALERS WILL INSPECT THE CABLE AND, AS NECESSARY, ADD PROTECTIVE TUBING FREE OF CHARGE. THE RECALL BEGAN ON JULY 17, 2012. OWNERS MAY CONTACT PREVOST AT 1-418-883-2888. The repair is free at any franchised dealer of your brand.
Read the full explainer → 10V-117 Open recall Mar 24, 2010
PREVOST CARS, INC.
EQUIPMENT ADAPTIVE/MOBILITY
PREVOST HAS NOTIFIED NHTSA OF A DEFECT IN CERTAIN MODEL YEAR 2008-2010 MOTOR COACHES FITTED WITH RICON PUBLIC USE LIFTS. THE RESTRAINT BELT ON THESE LIFTS WAS DESIGNED TO PREVENT THE LIFT FROM MOVING, UNLESS THE TONGUE OF THE BELT IS FULLY ENGAGED AND LATCHED IN THE BUCKLE. RICON HAS DISCOVERED, HOWEVER, THAT IT IS POSSIBLE FOR THE OPERATOR TO INSERT THE BELT TONGUE INTO THE BUCKLE WITHOUT FULLY ENGAGING THE LATCHING MECHANISM. IN THIS CASE, THE RESTRAINT BELT WOULD APPEAR TO BE LATCHED, AND THE OPERATOR COULD RUN THE LIFT. IF THE RESTRAINT BELT TONGUE IS NOT FULLY ENGAGED INTO THE RESTRAINT BELT BUCKLE, AND LATCHED, THE LIFT MAY OPERATE WITH AN OCCUPANT ON THE PLATFORM.
Risk: THE USER OF THE LIFT COULD BE INJURED SHOULD THE LIFT MOVE WITHOUT THE RESTRAINT BELT PROPERLY BUCKLED.
Remedy: PREVOST COACH IS WORKING WITH RICON AND PREVOST WILL BE HANDLING THE REMEDY FOR THIS CAMPAIGN THROUGH SAFETY RECALL (SR10-19). PREVOST WILL PROVIDE CUSTOMERS WITH A WARNING DECAL AND A DVD-BASED TRAINING AID. THE RECALL BEGAN ON JUNE 14, 2010. OWNERS MAY CONTACT PREVOST TECHNICAL PUBLICATIONS AT 1-418-831-5432 X 235 OR BY EMAIL AT DOMINIQUE.GAGNON@VOLVO.COM. The repair is free at any franchised dealer of your brand.
Read the full explainer →