Home/Recall report

2022 Blue Bird Vision School Bus — federal recalls on file

16 federal recalls reported for the 2022 Blue Bird Vision School Bus

These are federal recalls reported for the 2022 Blue Bird Vision School Bus. A recall may apply only to certain VIN ranges or production windows. To confirm whether your specific VIN is in the affected window, use NHTSA's official per-VIN lookup or enter your VIN on our check page.

24V-758 Open recall Oct 11, 2024

Blue Bird Body Company

EQUIPMENT:OTHER:LABELS

Blue Bird Body Company (Blue Bird) is recalling certain 2019-2024 Vision and All American school buses. The emergency exit label operating instructions lettering is too small and may be difficult to read. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 217, "Bus Emergency Exits and Window Retention and Release."

Risk: An emergency exit label that is difficult to read can prevent or delay the use of the emergency exit, increasing the risk of injury.

Remedy: Dealers will replace the emergency exit label, free of charge. Owner notification letters were mailed December 9, 2024. Owners may contact Blue Bird Customer Service at 478-822-2242. Blue Bird's number for this recall is R23CK (SB). The repair is free at any franchised dealer of your brand.

Read the full explainer →
24V-543 Open recall Jul 19, 2024

Blue Bird Body Company

STRUCTURE:BODY:ROOF AND PILLARS

Blue Bird Bus Company (Blue Bird) is recalling certain 2019-2023 Vision, All American Front Engine, and All American Rear Engine school buses. An exterior roof joint may have been manufactured with insufficient strength that can allow the roof panels to separate in a crash. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 221, "School Bus Body Joint Strength."

Risk: Roof panels that separate during a crash can increase the risk of injury.

Remedy: Dealers will inspect the roof panel joints and install additional rivets as necessary, free of charge. Owner notification letters were mailed September 17, 2024. Owners may contact Blue Bird customer service at 1-478-822-2242. The repair is free at any franchised dealer of your brand.

Read the full explainer →
24V-365 Open recall May 23, 2024

Blue Bird Body Company

FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY

Blue Bird Body Company (Blue Bird) is recalling certain 2021-2023 Vision school buses. The diesel tank that supplies the fuel fired heater was improperly designed and may leak fuel. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 301, "Fuel System Integrity."

Risk: A fuel leak onto the road creates a hazard for other road users, increasing the risk of a crash. Additionally, a fuel leak in the presence of an ignition source increases the risk of a fire.

Remedy: Dealers will repair the tank, free of charge. Owner notification letters were mailed July 08, 2024. Owners may contact Blue Bird customer service at 1-478-822-2242. Blue Bird's number for this recall is R24DA. The repair is free at any franchised dealer of your brand.

Read the full explainer →
24V-078 Open recall Feb 7, 2024

Blue Bird Body Company

SEATS

Blue Bird Body Company (Blue Bird) is recalling certain 2020-2024 Vision 2020-2023 All American school buses. The convertible seats may have been incorrectly installed, which can result in an unsecured seat. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 210, "Seat Belt Assembly Anchorages."

Risk: An unsecured seat may not adequately restrain an occupant, increasing the risk of injury during a crash.

Remedy: Dealers will inspect and repair the seat, free of charge. Owner notification letters were mailed March 04, 2024. Owners may contact Blue Bird customer service at 1-478-822-2242. Blue Bird's number for this recall is R24CM-SB. The repair is free at any franchised dealer of your brand.

Read the full explainer →
24V-068 Open recall Feb 2, 2024

Blue Bird Body Company

ELECTRICAL SYSTEM:SOFTWARE

Blue Bird Body Company (Blue Bird) is recalling certain 2021-2024 Vision school buses. Firmware in the multiplex module may cause the warning lights to deactivate and the stop arm to retract without warning.

Risk: An unintended deactivation of the warning lights and retraction of the stop arm during use increases the risk of a crash or injury.

Remedy: Dealers will update the multiplex firmware, free of charge. Owner notification letters were mailed March 25, 2024. Owners may contact Blue Bird customer service at 1-478-822-2242. Blue Bird's number for this recall is R24CX (SB). The repair is free at any franchised dealer of your brand.

Read the full explainer →
23V-425 Open recall Jun 13, 2023

Blue Bird Body Company

ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL, SERVICE BRAKES, AIR

Blue Bird Body Company (Blue Bird) is recalling certain 2021-2024 All American and 2021-2022 Vision school buses. A software error in the instrument cluster may cause the air pressure gauges and the visual and audio low air warnings to not function. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 121, "Air Brake Systems."

Risk: Air gauges and warnings that do not alert the driver to air pressure loss can result in driving without functioning brakes, increasing the risk of a crash.

Remedy: Dealers will update the instrument cluster software, free of charge. Owner notification letters were mailed July 27, 2023, 2023. Owners may contact Blue Bird's customer service at 1-478-822-2242. Blue Bird's number for this recall is R23CH (School Bus). The repair is free at any franchised dealer of your brand.

Read the full explainer →
22V-739 Open recall Oct 5, 2022

Blue Bird Body Company

ENGINE, FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS

Blue Bird Body Company (Blue Bird) is recalling certain 2022-2023 Vision school buses equipped with a 7.3L gasoline engine. The transmission cable may not have sufficient clearance from the gasoline fuel supply line at the left rear corner of the engine, which can result in a fuel leak.

Risk: A fuel leak in the presence of an ignition source increases the risk of a fire.

Remedy: Dealers will inspect and reroute the transmission cable, free of charge. Owner notification letters were mailed February 9, 2023. Owners may contact Blue Bird's customer service at 1-478-822-2242. Blue Bird's number for this recall is R22CB (School Bus). The repair is free at any franchised dealer of your brand.

Read the full explainer →
22V-578 Open recall Aug 4, 2022

Blue Bird Body Company

FUEL SYSTEM, OTHER:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS

Blue Bird Body Company (Blue Bird) is recalling certain 2018-2023 Blue Bird Vision transit buses equipped with Roush fuel return lines included in GEN 4 and GEN 5 LPG Conversion Systems that were installed on vehicles sold or registered in Connecticut, Delaware, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, Washington D.C., West Virginia, and Wisconsin. The zinc-plating on the fuel return line may break away when contacted by road debris, causing two dissimilar metals on the fuel line to contact each other and corrode.

Risk: A corroded fuel line can leak fuel, increasing the risk of a fire.

Remedy: Dealers will replace the fuel return lines, free of charge. Owner notification letters were mailed May 24, 2023. Owners may contact Blue Bird's customer service at 1-478-822-2242. Blue Bird's number for this recall is R22BX-NSB. The repair is free at any franchised dealer of your brand.

Read the full explainer →
22V-579 Open recall Aug 4, 2022

Blue Bird Body Company

FUEL SYSTEM, OTHER:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS

Blue Bird Body Company (Blue Bird) is recalling certain 2017-2023 Blue Bird Vision school buses equipped with Roush fuel return lines included in GEN 4 and GEN 5 LPG Conversion Systems that were installed on vehicles sold or registered in Connecticut, Delaware, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, Washington D.C., West Virginia, and Wisconsin. The zinc-plating on the fuel return line may break away when contacted by road debris, causing two dissimilar metals on the fuel line to contact each other and corrode.

Risk: A corroded fuel line can leak fuel, increasing the risk of a fire.

Remedy: Dealers will replace the fuel return lines, free of charge. Owner notification letters were mailed May 24, 2023. Owners may contact Blue Bird's customer service at 1-478-822-2242. Blue Bird's number for this recall is R22BX-SB. The repair is free at any franchised dealer of your brand.

Read the full explainer →
22V-505 Open recall Jul 14, 2022

Blue Bird Body Company

ELECTRICAL SYSTEM:PROPULSION SYSTEM

Blue Bird Body Company (Blue Bird) is recalling certain 2018-2022 All American and Vision school buses equipped with Cummins PD7000 Electric Drivetrains containing an electric air compressor. The air compressor housing is improperly grounded, causing electrical voltage greater than 50V AC during operation.

Risk: An improperly grounded air compressor can cause electric shock, increasing the risk of injury.

Remedy: Dealers will install an electrical ground strap between the compressor motor housing and vehicle chassis, free of charge. Owner notification letters were mailed February 6, 2023. Owners may contact Blue Bird's customer service at 1-478-822-2242. Blue Bird's number for this recall is R22BY-SB. The repair is free at any franchised dealer of your brand.

Reference campaign 22V505000 with your dealer.

22V-274 Open recall Apr 25, 2022

Blue Bird Body Company

FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS

Blue Bird Body Company (Blue Bird) is recalling certain 2022-2023 Vision school buses. The fuel supply line was incorrectly routed, allowing it to chafe against a bolt head, which can damage the line and create a fuel leak.

Risk: A fuel leak increases the risk of a fire.

Remedy: Dealers will reroute the fuel line, and replace the fuel line if any damage is found, free of charge. Owner notification letters are expected to be mailed on June 21, 2022. Owners may contact Blue Bird's customer service at 1-478-822-2242. Blue Bird's number for this recall is R22BU-SB. The repair is free at any franchised dealer of your brand.

Read the full explainer →
21V-778 Open recall Oct 6, 2021

Blue Bird Body Company

SERVICE BRAKES, HYDRAULIC:CRITICAL FASTENERS, SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS

Blue Bird Body Company (Blue Bird) is recalling certain 2022 Vision school buses equipped with Ford 7.3L engines. The retaining clamp used to secure the hydraulic brake line near the engine may not have been installed, which could cause the brake line to rub which could cause a brake fluid leak and result in a loss of brake function.

Risk: Loss of braking ability increases the risk of a crash.

Remedy: Dealers will inspect the hydraulic brakes lines, and install any missing hardware, free of charge. Owners letters were mailed on November 30, 2021. Owners may contact Blue Bird's customer service at 1-478-822-2242. Blue Bird's number for this recall is R21BN-SB. The repair is free at any franchised dealer of your brand.

Read the full explainer →
21V-696 Open recall Sep 8, 2021

Blue Bird Body Company

BACK OVER PREVENTION: SENSING SYSTEM: CAMERA

Blue Bird Body Company (Blue Bird) is recalling certain 2022 Vision school buses equipped with cross-view mirrors and a Mobileye collision mitigation system. Due to the current placement of the Mobileye camera, the camera could partially or fully obstruct the driver's view of the passenger side cross-view mirror. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."

Risk: An obstructed view of the passenger side cross-view mirror increases the risk of injury for pedestrians.

Remedy: Dealers will change the location of the camera and update the software, free of charge. Owners were notified of the defect on November 2, 2021. Owner notification letters were mailed on March 31, 2022. Owners may contact Blue Bird's customer service at 1-478-822-2242. Blue Bird's number for this recall is R21BL-SB. The repair is free at any franchised dealer of your brand.

Read the full explainer →
21V-284 Open recall Apr 22, 2021

Blue Bird Body Company

SERVICE BRAKES, AIR

Blue Bird Body Company (Blue Bird) is recalling certain 2020-2022 Vision and All American school buses. A retainer was not properly seated in the SC-3 single check valve and may not provide source air isolation when pressure is applied. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 121, "Air Brake System."

Risk: Unintended spring brake application may occur, increasing the risk of a crash.

Remedy: Dealers will replace the SC-3 check valves, free of charge. Owner notification letters were mailed on November 18, 2021. Owners may contact Blue Bird customer service at 1-478-822-2242. Blue Bird's number for this recall is R21BE-SB. The repair is free at any franchised dealer of your brand.

Read the full explainer →
21V-083 Open recall Feb 17, 2021

Blue Bird Body Company

ELECTRONIC STABILITY CONTROL (ESC)

Blue Bird Body Company (Blue Bird) is recalling certain 2021-2022 Vision and 2022 All American school buses equipped with hydraulic brakes and electronic stability control (ESC). The Hydraulic Brake control unit (ECU) may not have been programmed correctly, possibly causing the ESC to malfunction.

Risk: If the electronic stability control does not function properly, it can increase the risk of a crash or injury.

Remedy: Blue Bird will notify owners, and dealers will inspect the hydraulic brake ECU and repair it as necessary, free of charge. The recall began on April 9, 2021. Owners may contact Blue Bird customer service at 1-478-822-2242. Blue Bird's number for this recall is R21BC-SB. The repair is free at any franchised dealer of your brand.

Read the full explainer →
21V-070 Open recall Feb 12, 2021

Blue Bird Body Company

SEAT BELTS:REAR/OTHER:ANCHORAGE

Blue Bird Body Company (Blue Bird) is recalling certain 2020-2022 Vision and All American buses. The seats with integrated 3-point seat belts may have been installed incorrectly. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 210, "Seat Belt Assembly Anchorages."

Risk: An incorrectly installed seat can increase the risk of injury in the event of a crash.

Remedy: Blue Bird will notify owners, and dealers will inspect the seats and install any missing hardware, as necessary, free of charge. The recall is expected to begin April 9, 2021. Owner notification letters were mailed February 03, 2022. Owners may contact Blue Bird customer service at 1-478-822-2242. Blue Bird's number for this recall is R21BB-SB. The repair is free at any franchised dealer of your brand.

Read the full explainer →