23V-448 Open recall Jun 27, 2023
Lion Electric Company
ENGINE AND ENGINE COOLING
Lion Electric Company (Lion) is recalling certain 2019-2025 LionC hybrid electric school buses. The surge tank may move and crack the firewall, allowing the tank to contact and damage the high-voltage cables.
Risk: Damaged high-voltage cables can shut down the high-voltage circuit, causing a loss of steering assistance or drive power and reducing braking power, increasing the risk of a crash.
Remedy: Lion technicians will install a new surge tank support bracket to the accessory plate, free of charge. Owner notification letters were mailed August 21, 2023. Owners may contact Lion customer service at 1-855-546-6706. Lion's number for this recall is R2023-006. The repair is free at any franchised dealer of your brand.
Read the full explainer → 23V-036 Open recall Jan 30, 2023
Lion Electric Company
STEERING:HYDRAULIC POWER ASSIST:PUMP
Lion Electric Company (Lion) is recalling certain 2019-2023 LionC school buses. The rubber mounts used to absorb vibrations from the main hydraulic pump may wear prematurely and fail, resulting in an unsecured pump.
Risk: An unsecured hydraulic pump can cause a loss of power steering assist. In addition, the unsecured pump may damage the low-voltage harness and result in the loss of high voltage power. Either of these scenarios can increase the risk of a crash.
Remedy: Lion Electric Company will dispatch a technician to remove the rubber mounts, free of charge. Owner notification letters were mailed February 7, 2023. Owners may contact Lion customer service at 1-855-546-6706. The repair is free at any franchised dealer of your brand.
Read the full explainer → 21V-968 Open recall Dec 14, 2021
Lion Electric Company
ELECTRICAL SYSTEM:WIRING:FUSES AND CIRCUIT BREAKERS, SERVICE BRAKES, HYDRAULIC:POWER ASSIST:ELECTRIC, STEERING:ELECTRIC POWER ASSIST SYSTEM
Lion Electric Company is recalling certain 2017-2021 LionC school buses. A 12V circuit breaker switch may fail, causing a loss of braking and steering assist.
Risk: A loss of braking and steering assist increases the risk of a crash.
Remedy: Lion Electric Company will inspect and repair the 12V circuit breaker switch, free of charge. Owner notification letters were mailed January 10, 2021. Owners may contact Lion Electric Company customer service at 1-855-546-6706. The repair is free at any franchised dealer of your brand.
Read the full explainer → 20V-697 Open recall Nov 12, 2020
Lion Electric Company
SEAT BELTS
Lion Electric Company (Lion Electric) is recalling certain 2016-2019 Lion C and Lion 360 school buses equipped with wheelchair lifts. The shoulder belt and ground anchors intended to hold a wheelchair in place may detach in the event of a crash. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 222, "School Bus Passenger Seating and Crash Protection."
Risk: If the shoulder belt and ground anchors detach during a crash, their would be an increased risk of injury to the occupant.
Remedy: Lion Electric has notified owners, and dealers will add a rivet to reinforce the floor and change the screws on the seat belt, free of charge. The recall began November 23, 2020. Owners may contact Lion Electric customer service at 1-855-546-6706. The repair is free at any franchised dealer of your brand.
Read the full explainer → 20V-333 Open recall Jun 9, 2020
Lion Electric Company
SEAT BELTS:FRONT, SEAT BELTS:FRONT:ANCHORAGE
Lion Electric Company (Lion) is recalling certain 2012-2020 Lion C and Lion 360 hybrid electric school buses. The driver's seat belt anchor may have been attached with incorrect hardware, possibly causing the seat belt to not be anchored properly.
Risk: In the event of a crash, a seat belt that is not be properly anchored can increase the risk of injury.
Remedy: Lion will notify owners and will replace the seatbelt hardware, free of charge . The recall began July 20, 2020. Owners may contact Lion customer service at 1-855-546-6706. The repair is free at any franchised dealer of your brand.
Read the full explainer → 20V-123 Open recall Mar 2, 2020
Lion Electric Company
STEERING
Lion Electric Company (Lion) is recalling certain 2015-2020 Lion C and Lion 360 electric and diesel school buses. The bolts connecting the pitman arm and I-shaft to the power steering box may loosen, resulting in a complete loss of steering control.
Risk: A complete loss of steering can increase the risk of a crash.
Remedy: Lion has notified owners and will replace the pitman and I-shaft bolts. The recall began March 12, 2020. Owners may contact Lion customer service at 1-855-546-6706. The repair is free at any franchised dealer of your brand.
Read the full explainer →